#110 SOLVENT FREE EPOXY STAIR CAULK PART A

Complies with OSHA's Hazard Communication Standard CFR 1910-1200

 
I. Chemical Product and Company Identification
Material Identity   HMIS: H: 1/F: 0/R: 0/P: B
 

Product Code and Name: #110, Solvent Free Epoxy Stair Caulk Adhesive, Part A

Product Class: Adhesive

DOT Class: Not Regulated

Manufactured for:

R.C. Musson Rubber Co.

1320 E. Archwood Ave.

Akron, OH 44306

24 Hour Emergency: Chemtree 1(800) 424-9300
Date Prepared: May 11, 2001 Date Revised: Original
 
II. Composition/Information on Hazardous Ingredients
Component
OSHA PEL
ACHIH TLV
%
LD50/LC50
CAS Number

Epicholorohydrin Bisphenol A Resin

Epichlorohydrin Polyglycol Resin

NE

NE

NE

NE

40-45

10-15

>5000 MG/KG

>2000 MG/KG

25089-99-8

41638-13-5
 
III. Physical Data
Vapor Density (air=1):
 NA
Boiling Point:
NA
Density:
 1.45
Vapor Pressure:
NA
Solubility in Water:
None
Appearance and Odor:
Off white medium paste, mild epoxy resin odor
Evaporation Rate (butyl acetate=1):
None
V.O.C:
 < 30G/L  max
% Solids:
97%
 
IV. Fire and Explosion Hazards
Flash Point: (Method Used):
>250°F (T.O.C)
Flammable Limits:
NA
Flammability Classification:
OSHA: None
DOT:
 None
Extinguishing Media:
Carbon Dioxide, Dry Chemical or Foam
Special Fire Fighting Procedures:
Wear self contained breathing apparatus
Unusual Fire and Explosion Hazards:
None
 
V. Reactivity Data
Stability:
 Stable
Conditions to Avoid:
In reaction with many curing agents, considerable heat is released
Incompatibility (Materials to Avoid):
None known
Hazardous Decomposition Products:
Carbon Monoxide, Carbon Dioxide, aldehydes and acids from incomplete combustion
Hazardous Polymerization:
Will not occur
 
VI. Health Hazard Data
Effect of Overexposure:

Cronic: Prolonged or repeated skin exposure can cause mild skin irritation.

Acute: Prolonged or repeated skin exposure can cause mild skin irritation. Mildly irritating to the eyes.

Emergency and First Aid Procedures:

Eyes: Flush with water for fifteen minutes. Get medical attention if irritation persists.

Skin: Wash with soap and water or waterless skin cleanser followed by soap and water. Get medical help if irritation persists.

Ingestion: Seek medical attention.

Inhalation: Remove victim to fresh air. Give artifical respiration if not breathing. Get medical attention.

 
VII. Precaution for Safe Handling and Use
Steps to take in case material is spilled or released:
Soak up with sand or clay. Place in non-leaking container.
Waste disposal method:
Dispose of according toFederal, State and Local regulations.
Handling and storage precautions:
Keep container tightly closed. Store in a cool dry place. Wash with soap and water before eating, drinking, smoking or using the toilet facilities. Launder contaminated clothing before reuse.
Transportation Data:
See Section I.
Other Precautions:
Keep out of reach of children!
 
VIII. Control Measures
Respiratory Protection: Not usually required. Use respiratory protection if vapor levels are at or above TLV levels. Use NIOSH approved respirator.
Ventilation: Good General/Local ventilation to control vapor levels below TLV.
Protective gloves: Chemical resistant gloves.
Eye protection: Normal precautions.
Hygenic Practices: Good general cleanliness and hygiene.
 
Disclaimer:This Safety Data Sheet was prepared to protect against any reasonable exposure to consumers or employees arising out of the intended use of the product and to provide them with information regarding potential hazards contained in the product. Under varied circumstances the hazardous ingredients may pose a lesser or greater hazard. Because of the scientific data contained in these sheets was from test performed by agencies other than the manufacturer. The company cannot gaurentee its accuracy. The Manufacturer makes no warranty of any kind, expressed or implied. The user must assume all risk and liability resulting from reliance on the information contained on this Material Safety Sheet and the use of this product, whether used in combination with other products or singularly.